Ceiling liner swap Soft to Hard 94 Legacy wagon

[moosens]

Labor Day's labor for me was as the title says.

For those who are timid about trying something like this I'd like to tell you it's not he easiest job when alone but it's entirely possible in about 2 hours if you have to cut out for an aftermarket sunroof.

 

Said sunroof was the downfall of the fabric ceiling liner. (Alpine Sport) Outdoor series came with cloth liners and a woven cloth seat set. The leaky sunroof also caused the power window relay to short , or the wires anyways. So the sunroof is well sealed and now the crappy cloth liner has been replaced with the typical hard vinyl covered liner.

 

Managed to keep a few pillar covers up while doing it. Got one side started by hanging it in the side trim I left up but loose. Little by little got the other side hung in the center and worked my way to the back and sealed that up , set the rear cargo light in and rear trim header. Couple of push pins back there too. Then worked the front and slowly got my way around tucking it all in place with wires through the holes etc.

 

Used the old liner as a template and fine tuned the sunroof radius corners. Did pretty good measuring a lot and being patient. But the cloth liner is a little off for the dome light , so I left that for another day. Also , the hard liner takes a dip forward of the sunroof which has left a gap. I'll come up with something there.

 

Happy Labor Day !

Union !